Rivoli , P. What is a motorcycle repair manual: John Wiley and Sons. Skip to content. References Freeman, H. Related Posts. Page Adjusting The Rear Brake Light Switch If there is air in the hydraulic system, have a Yamaha dealer bleed the system be- fore operating the motorcycle. Air in the hydraulic system will diminish 1. Rear brake light switch the braking performance, which 2.
Page Checking The Front And Rear Brake Pads Before riding, check that the brake fluid ified in the periodic maintenance and Yamaha dealer replace the brake pads is above the minimum level mark and lubrication chart. Each brake pad is as a set.
Water will significantly brake fluid at the intervals specified in lower the boiling point of the fluid the NOTE after the periodic mainte- and may result in vapor lock.
To check the drive chain slack 1. Place the motorcycle on a level surface and hold it in an upright a. Lithium-soap-based grease all-purpose grease Recommended lubricant: Engine oil EW Recommended lubricant: Lithium-soap-based grease all-purpose grease Page Checking The Wheel Bearings 2.
Hold the lower ends of the front fork legs and try to move them for- ward and backward. If any free play can be felt, have a Yamaha dealer check or repair the steer- ing.
Page Battery Avoid any contact with To charge the battery skin, eyes or clothing and al- Have a Yamaha dealer charge the bat- ways shield your eyes when tery as soon as possible if it seems to working near batteries.
In case have discharged. Radiator fan fuse: 7. Page Replacing The Headlight Bulb 3. If the fuse immediately blows again, have a Yamaha dealer check the electrical system.
Headlight coupler 1. Headlight bulb holder 2. Install the lens by installing the fied. Install the headlight bulb cover, EC and then connect the coupler. Have a Yamaha dealer adjust the Do not overtighten the screws, oth- headlight beam if necessary. It is advisable to have a Yamaha 4. Lift the front wheel off the ground dealer service the wheel. Install the brake hose holders by Make sure that the slot in the speedom- dealer service the wheel.
Cotter pin 1. Brake caliper bracket 2. Nut 2. Right wheel axle guide 7. Pull the wheel axle out along with 3. Bolt 3. Remove the axle nut and the left the right wheel axle guide, remove 4. Page Troubleshooting 1. Install the wheel, right wheel axle self. However, should your motorcycle Brake caliper bolt: guide, and caliper bracket by in- require any repair, take it to a Yamaha 40 Nm 4. Page Troubleshooting Charts Remove the spark plugs and check the electrodes. The engine does not start.
Have a Yamaha dealer check the vehicle. Check the battery. Battery The engine turns over The battery is good. Page 94 Start the engine. If the engine overheats again, have a The coolant level Yamaha dealer check and repair the cooling system. NOTE: If coolant is not available, tap water can be temporarily used instead, provided that it is changed to the recommended coolant as soon as possible.
Be a windshield: Do not use strong on salt-sprayed roads sure to avoid using cloths or cleaners or hard sponges as Since sea salt or salt sprayed on roads sponges which have been in Dry the motorcycle with a chamois Make sure that there is no oil or what products to use. Remove the spark plug caps and Before storing your motorcycle for sev- spark plugs. Pour a teaspoonful of engine oil Short-term 1. Follow all the instructions in the into each spark plug bore.
Lubricate all control cables and NOTE: Make any necessary repairs before the pivoting points of all levers and storing the motorcycle. Check and, if necessary, correct the tire air pressure, and then lift the motorcycle so that both of its wheels are off the ground.
Page Identification Numbers Record the key identification number, vehicle identification number and mod- el label information in the spaces pro- vided below for assistance when ordering spare parts from a Yamaha dealer or for reference in case the vehi- cle is stolen. Key identification number 1. Page Model Label The model label is affixed to the frame under the seat. See page for seat removal and installation procedures. Record the information on this label in the space provided.
This information will be needed when ordering spare parts from a Yamaha dealer. Print page 1 Print document pages. Rename the bookmark. Delete bookmark? Cancel Delete.
Delete from my manuals? Sign In OR. Don't have an account? Sign up! A downloadable repair manual, also termed factory service manual, is a digitally delivered book of repair instructions that describes the maintenance, service and repair procedures for the complete motorcycle. Yamaha workshop manuals for download, free!
Every thing! Go to download Yamaha YZFR repair manual, termed YZFR service manual or YZFR workshop manual, is a book of motorcycle repair instructions that guides a mechanic on how to fix, service or overhaul the sport bike made by Yamaha back to working order. The downloadable handbook is instantly attainable and applies to thru Yamaha YZFR models.
0コメント